Journal of Petroleum & Environmental Biotechnology

Feedback control over the chlorine disinfection process at a wastewater treatment plant using a Smith Predictor, a method of characteristics and odometric transformation

2^nd World Congress on Petrochemistry and Chemical Engineering

October 27-29, 2014 Embassy Suites Las Vegas, USA

Feridun Demir and Spyros A Svoronos

Scientific Tracks Abstracts: J Pet Environ Biotechnol

Abstract:

Chlorine disinfection of wastewater at the Kanapaha Water Reclamation Facility in Gainesville, Florida, was investigated to design an appropriate feedback controller because this facility has a large and variable dead-time. Cascade control and Dead-Time Compensation were applied to control the performance of this type of system using the Method of Characteristics and Odometric Transformation. The cascade control scheme features a slave controller with a probe located proximate to the dosage point; therefore, this system can be tuned e ffi ciently. The other controller in the cascade is a master controller that adjusts the set point of the slave controller. The master is affected by a large and variable dead-time. However, by using the Odometric Transformation, the reactor model can be written as a system with a constant dead-time. An Odometric Transformation replaces time with β in the model and transforms the system dynamics to a constant time delay model. The Method of Characteristics was used to transform the partial differential equations for the chlorine disinfection reactions into ordinary differential equations. Afterward, the Smith Predictor was used to design a Dead-Time Compensation for the master controller.The resulting equations were solved numerically, and the maximum numbers for the reactor and control variables were calculated using an open loop simulation program. The delays were calculated for each system, and the highest delay was calculated when the numbers for the reactor were the maximum. The simulation suggests that a 20-sec time increase is adequate for conducting a discrete approximation for the continuous system.

Biography :

Feridun Demir obtained his Ph.D. degree from the Department of Chemical Engineering at the University of Florida, and is currently aProfessor of Chemical Engineering at OsmaniyeKorkut Ata University in Osmaniye, Turkey.